MATERIAL
SAFETY DATA SHEET
CHEMICAL
PRODUCT AND COMPANY INFORMATION
COMPLEX
CHEMICAL COMPANY
177 COMPLEX
CHEMICAL ROAD
MADISON PARISH
PORT
TALLULAH,
LA. 71282
318-574-0382
PRODUCT NAME : DOT 3 E BRAKE FLUID
**RESTRICTED
FOR EXPORT ONLY**
CAS NUMBER : NONE FOR MIXTURES
GENERIC CHEMICAL NAME: NONE
PRODUCT TYPE: MIXTURE
PREPARATION/REVISION
DATE: 01/01/2010
TRANSPORTATION EMERGENCY
PHONE NUMBER: 318-574-0382
COMPOSITION/INFORMATION
ON INGREDIENTS
Diethylene
glycol 10
– 20 111-46-6
*
Diethylene glycol monobutyl ether 5 – 10 112-34-5
*
Triethylene glycol monobutyl ether 5 – 10 143-22-6
*
Triethylene glycol monoethyl ether 8 - 15 112-50-5
*
Diethylene glycol monopropyl ether 40
- 60 6881-94-3
Polypropylene
glycol 5 – 10 25322-69-4
Triethylene
glycol 3 – 8 112-27-6
Tetraethylene
glycol 3 – 8 112-60-7
*
Denotes Sara 313 chemicals
HAZARDS
IDENTIFICATION
This
material has a low hazard under normal handling conditions.
HMIS HAZARD
RATING
HEALTH
HAZARD 1 FIRE HAZARD 1 REACTIVITY 0
Based
on the National Paint and Coatings Association HMIS rating system.
FIRST AID
MEASURES
EYES: Any material that contacts the eyes should be washed
out immediately and medical attention obtained if any symptoms are present
after washing.
ORAL: Give two glasses of water and consult medical
personnel. Do not induce vomiting.
SKIN: Wash contaminated skin with soap and water.
INHALATION: Remove to fresh air and consult medical personnel.
FIRE FIGHTING
MEASURES
FLASH POINT: 203 C
UPPER FLAMMABLE
LIMIT:
Not
determined
LOWER FLAMMABLE
LIMIT:
1.5
EXTINGUISHING MEDIA: Dry chemical,
CO2, foam, or water fog
FIRE FIGHTING
PROCEDURES: Wear self contained breathing apparatus with full
face piece and protective clothing.
UNUSUAL FIRE &
EXPLOSION HAZARDS: None known
AUTO IGNITION POINT: Not determined
EXPLOSION DATA: None known
ACCIDENTAL
RELEASE MEASURE
Small
spills should be collected with absorbent material. Large spills should be contained to keep from entering
drains, sewers, or streams. Flush
area with water spray.
HANDLING AND
STORAGE
MAXIMUM HANDLING
TEMPERATURE: Not determined
HANDLING PROCEDURES: Keep containers closed when not in use. Wash thoroughly after handling. Empty containers contain product
residue which may exhibit hazards of product.
MAXIMUM STORAGE
TEMPERATURE: None established
STORAGE PROCEDURES: No special storage precautions required.
EXPOSURE
CONTROLS/PERSONAL PROTECTION
VENTILATION
PROCEDURES: Use with adequate
ventilation.
GLOVES
PROCEDURES: PVC or nitrile
EYE
PROTECTION: Safety glasses with
side shields of goggles.
RESPIRATORY
PROTECTION: Under normal
circumstances none is needed.
CLOTHING
RECOMMENDATION: Long sleeve shirt is recommended.
PHYSICAL AND
CHEMICAL PROPERTIES
VAPOR PRESSURE: less than 0.1 @ 20 C
pH: 7.0 – 11.5
SPECIFIC GRAVITY: 1.023 – 1.035
WATER SOLUBILITY: complete
PERCENT VOLATILE: Unknown
PERCENT VOC: Not determined
VAPOR DENSITY: Not determined
EVAPORATION RATE: less than 60% in 72 hours
ODOR: Mild etheric odor
APPEARANCE: clear to amber
VISCOSITY: less than 1500 @ -40 F
BOILING POINT: 205 C minimum
STABILITY AND
REACTIVITY
STABILITY: Stable
DECOMPOSITION
TEMPERATURE: Not determined
INCOMPATIBILITY: None known
POLYMERIZATION: Will not occur.
THERMAL
DECOMPOSITION: Carbon dioxide and probably carbon monoxide
TOXICOLOGICAL
INFORMATION
ORAL TOXICITY: Lethal dose for human reported to be 100 ml.
EYE IRRITATION: Low hazard for normal handling. May cause slight irritation.
SKIN IRRITATION: Prolong contact could result in mild irritation.
RESPIRATORY IRRITATION: Very toxic in particulate form upon inhalation.
OTHER EXPOSURE
LIMITS: None known
DISPOSAL
CONSIDERATION
WASTE DISPOSAL: Dispose of observing all local, state, and federal
laws.
TRANSPORTATION
INFORMATION
US DOT (BULK): Not Regulated
US DOT (NON BULK): Not Regulated
IMDG: This material is not classified as dangerous under
IMDG regulations.
REGULATORY
INFORMATION
US TSCA INVENTORY: All components are on TSCA Inventory
SARA EXT. HAZ. SUBST.: None
SARA SECTION 313: See section 2
CERCLA HAZARDOUS
SUBSTANCES: None Known